filename: tfs 70ba.doc version 1.0 18.08.2006 vi telefilter filter specification tfs 70ba 1/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m measurement condition ambient temperature: 23 c input pow er level: 0 dbm terminating impedance: * input: 2900 ? || -3,8 pf output: 2900 ? || -3,8 pf external coil: 820 nh ch aracteristics remark: the reference lev e l for the relativ e attenuation a rel of the tfs 70ba is the mini mum of the pass band attenuation a min . the minimum of the pass band attenuation a min is defined as the insertion loss a e . the centre frequency f c is the arithmetic mean v a lue of the upper and low e r frequencies at the 3 db filter attenuation lev e l relativ e to the insertion loss a e . the nominal frequency f n is fix ed at 70,0 mhz w i thout any tole rance. the giv en v a lues for both the relativ e attenuation a rel and the group delay ripple hav e to be achiev ed at the frequencies giv en below ev en if the centre frequency f c is shifted due to the temperature coefficient of frequency tc f in the operating temperature range and due to a production tolerance for the centre frequency f c . d a t a ty p. v a lue tolerance / limit insertion loss a e 3 , 7 d b m a x . 6 , 0 d b (reference level) nominal frequency f n - 7 0 , 0 m h z centre frequency at ambient temperature f c 70,002 mhz 70,0 0,015 mhz passband p b - f n 35 khz pass band ripple 0 , 5 d b m a x . 1 , 0 d b relativ e attenuation a rel f n ? f n 3 5 k h z 0 , 5 d b m a x . 1 , 0 d b f n 35 khz ? f n 4 7 k h z 2 , 0 d b m a x . 3 , 0 d b f n 60 khz ? f n 9 0 k h z 2 , 5 d b m i n . 1 , 0 d b f n 90 khz ? f n 4 5 0 k h z 1 0 d b m i n . 3 , 0 d b f n 450 khz ? f n 5 0 0 k h z 4 5 d b m i n . 3 5 d b f n 500 khz ? f n 1 0 mhz 4 3 d b m i n . 4 0 d b input pow er lev e l max . 8 d b m operating temperature range otr - - 5 c ... + 70c storage temperature range - - 30 c ... + 90c frequency inv e rsion temperature 2 5 c temperature coefficient of frequency t c f ** -0.043 ppm/k 2 *) the terminating impedances depend on paras itics and q-v a lues of matching element s and the board used, and are to be understo od as reference v a lues only . should there be additional ques tions do not hesitate to ask for an applic ation note or contac t our design team. **) ? f c (hz) = tc f (ppm/k 2 ) x (t - t o ) 2 x f to (mhz). ge ne ra te d: ch ecked / a p p r o v ed : vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 70ba.doc version 1.0 18.08.2006 vi telefilter filter specification tfs 70ba 2/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m f ilter ch aracteristic 69 69 . 2 69 . 4 69 . 6 69 . 8 70 70 . 2 70 . 4 70 . 6 70 . 8 71 -7 0 -6 3 -5 6 -4 9 -4 2 -3 5 -2 8 -2 1 -1 4 -7 0 f r e q ue nc y i n m h z m a g n itu d e in d b 69. 9 69. 95 70 70. 05 70. 1 -1 5 -1 0 -5 0 f r e que nc y i n m h z m a gni t ude i n db cons truc tion a nd pin c onne c t ion (all dimensions in mm) 13 , 3 0 , 2 6,5 0,2 1, 8 0, 2 1, 9 1 0 , 2 7, 6 2 0 , 2 1, 0 0 , 2 1,9 0,2 da t e c o d e 1 5 6 10 date code: y ear + w eek u 2006 v 2007 w 2008 ... 1 ground 2 ground 3 ground 4 ground 5 output 6 external coil 7 ground 8 ground 9 ground 10 input tfs 70ba u33 50 ? t est circu i t c1 l1 sa w l 2 c2 1, 2, 3, 4, 7, 8, 9 6 5 10 vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 70ba.doc version 1.0 18.08.2006 vi telefilter filter specification tfs 70ba 3/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m stability characteristics, reliability 100% screening tests : after the follow i ng tests the filter shall meet the w hole spec ification. electrical tests after test 4, test 5 and 7. 1. internal visual inspection: according to mil-std-883 method 2017 2. stabilization bake: 16 hrs at 125c under vacuum according to mil-std-883 method 1008 condition b 3. temperature cy cling: -55 c to 125c / 30 min. each / 10 cy cles din iec 68 part 2 ? 14 test n equivalent mil-std-202 method 107 4. burn-in: 160hrs at 125c ( no input pow er ) according to mil-std-883 method 1015 5. seal test: gross leak bubble test ? fluorocarbon liquid at 125c 5c mil-std-202 method 112 condition d fine leak spot test ? helium detector a ccording to mil-std-202 method 112 condition c 6. external visual inspection: according to mil-std-883 method 2009 qualification tests : 1. resistance to reflow possible: three times max.; solder heat (reflow ): for temperature conditions refer to the attached "air reflow temperature conditions" on page 4; 2. vibration: 10 hz to 2000 hz, 1,5 mm or max 20g respecti vely , 1 octave per min, 10 cy cles per plan, 3 plans; din iec 68 2 ? 6 3. shock: 500g, 1 ms, half sine w a ve, 3 shocks each plane; din iec 68 t2 - 27 , 7. radiation: 100 krad , escc detail specification no.22900 packin g tape & reel: iec 286 ? 3, w i th exception of value for n and minimum bending radius; tape ty pe ii, embossed carrier tape w i th top cover tape on the upper side; max. pieces of filters per reel: 1700 reel of empty components at start: min. 300 mm reel of empty components at start including leader: min. 500 mm trailer: min. 300 mm g do w ct f e g d1 p2 p1 po bo ao p u l l o ff di r e c t io n pi n m a r k e r ty p da t e c o d e ko t tape (al l di mensi ons i n mm) w : 24,00 +0,30/-0,10 po : 4,00 0,1 do : 1,50 +0,1/-0 e : 1,75 0,10 f : 11,50 0,10 g(min) : 0,60 p2 : 2,00 0,1 p1 : 12,00 0,1 d1(min) : 1,50 a o : 7,10 0,10 bo : 13,90 0,10 ct : 21,5 0,1 a c n w 1 w 2 r eel (all d i men s io n s in mm) a : 330 w 1 : 24,4 +2/-0 w 2 (max ) : 30,4 n(min) : 60 c : 13,0 +0,5/-0,2 the minimum bending radius is 45 mm. vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 70ba.doc version 1.0 18.08.2006 vi telefilter filter specification tfs 70ba 4/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m a i r re flow te mpe r a t ure c onditions conditions exposure average ramp-up rate (30c to 217c) less than 3c/second > 100c betw een 300 and 600 seconds > 150c betw een 240 and 500 seconds > 217c betw een 30 and 150 seconds peak temperature max. 260c time w i thin 5c of actual peak temperature betw een 10 and 30 seconds cool-dow n rate (peak to 50c) less than 6c/second time from 30c to peak temperature no greater than 300 seconds chip-mount air reflow profile temperature / c max. 260c 217c time / s max. 300 s 10 ... 30 s 30 ... 150 s vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 70ba.doc version 1.0 18.08.2006 vi telefilter filter specification tfs 70ba 5/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m history version reason of changes name date 1.0 - generation of filter specification strehl 18.08.2006 vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
|
